Global trade certification services

How to repair engine water inlet (repair method caused by car water inlet) Car water inlet is Global trade certification servicesa relatively common type of car fault. Once the engine water inlet causes a fault, relevant maintenance measures need to be taken in time to avoid further damage to the car. This article will introduce the reasons, judgment methods and repair methods of water entering the car engine. I. Causes of water inlet There are many reasons for water in the car, such as water leakage, broken or water leakage of the reservoir, the rupture of the camshaft seal, the puddle at the bottom of the car, the water level of the water tank, etc. And in most cases, the water entering the engine is caused by: 1. The drainage facilities of many small lanes are relatively simple, and it is difficult to rule out the water in the road area. If the owner encounters heavy rain or stagnant water during driving, and the speed is too fast, the wheels will form water flow, and the water will enter the engine air intake, radiator and chassis, and the danger of water entering the engine will follow.Two. Leakage in the water tank. If the water tank of the engine leaks, the water in the water tank will often seep into the engine. Therefore, the owner of the vehicle should regularly check the condition of the water tank of the vehicle when driving. If the water tank leaks, it needs to be replaced in time. 3. If the engine air intake is not closed, the engine air intake is not closed or the air intake is damaged, which may also cause water in the engine. In order to avoid this situation, car owners need to pay attention to such details and take good protective measures. II. Judgement method After water enters the car engine, the following situations generally occur: 1. The engine can't run when it starts, and the sound is louder than usual. Two. The vehicle cannot run normally after starting, resulting in problems such as shaking and power loss. 3. The water temperature gauge or detection instrument shows that the engine water temperature is too high. Four. When exhaust gas is discharged, white smoke is produced.If any of the above situations occur, it may mean that there is a water inlet failure in the engine and should be dealt with in time. III. Repair method 1. To repair the potential water leakage, first of all, it is necessary to detect the potential leakage, eliminate the leakage situation, and ensure that the next operation environment of the engine is clean, and there are no more water leakage points that may lead to water inlet. Two. Replace the damaged parts. If you find that the engine seal or gasket has been damaged, you need to replace it in time. At the same time, it is also necessary to check whether the oil seal, tire screw, water pump bearing and other parts are intact. If there is a problem, relevant replacement is also required. 3. Repair electrical appliances. If any electrical equipment is found to be damaged, such as igniters or electrical switches, it needs to be replaced or repaired. Four. Spraying the exhaust pipe, if it is found that a large amount of white smoke is generated when the car emits exhaust gas, it may be due to the erosion of rain inside the exhaust pipe, forming many impurities.In this regard, the exhaust pipe can be sprayed by thermal spraying method to ensure the qualification of exhaust emissions. 5. Remove the air intake and radiator. After troubleshooting all the potential water leakage, the air intake and radiator of the car need to be cleaned. Thoroughly remove the moisture in these parts to make the engine more stable. Based on the above repair methods, the fault of engine water inlet should be repaired and dealt with in time. After finding water in the car, the first thing that many car owners think of is to put it in a dry place to dry naturally, but this method is not only ineffective, but also easy to cause greater damage to the engine. Therefore, timely troubleshooting of potential water leakage and overhaul of engine parts is the key to solving the water inlet fault of automobile engines. In addition, pay attention to the daily maintenance of cars and prevent water ingress.

Contact Us
Phone：020-83484696